ZYNOLYTE PRODUCTS INC -- KLENKS EPOXY AVOCADO, 8303WZ -- 8010-00N065010 
=====================  Product Identification  =====================

Product ID:KLENKS EPOXY AVOCADO, 8303WZ
MSDS Date:06/27/1995
FSC:8010
NIIN:00N065010
=== Responsible Party ===
Company Name:ZYNOLYTE PRODUCTS INC
Address:2320 E DOMINGUEZ ST
City:CARSON
State:CA
ZIP:90749
Country:US
Info Phone Num:310-513-0700
Emergency Phone Num:303-623-5716;800-424-9300(CHEMTREC)
Preparer's Name:JOHN R KORDOSH
CAGE:25461
=== Contractor Identification ===
Company Name:ZYNOLYTE PRODUCTS CO
Address:2320 E DOMINGUEZ ST
Box:6244
City:CARSON
State:CA
ZIP:90749
Country:US
Phone:310-513-0700
CAGE:25461

=============  Composition/Information on Ingredients  =============

Ingred Name:ACETONE; (2-PROPANONE) (SARA 313) (CERCLA) VP:184 @ 68F
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 27%
OSHA PEL:1000 PPM
ACGIH TLV:750PPM/1000STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:TOLUENE (SARA 313) (CERCLA) VP:22 @ 68F
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 16%
OSHA PEL:200 PPM
ACGIH TLV:S, 50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:PROPANE VP:200 @ 100F
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 15%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT

Ingred Name:LACOLENE; (LIGHT ALIPHATIC PETROLEUM DISTILLATE BP
    188-232F) VP:90 @ 100F
CAS:64742-89-8
Fraction by Wt: 10%
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:BUTANE; (N-BUTANE) VP:37 @ 100F
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 10%
OSHA PEL:800 PPM
ACGIH TLV:800 PPM

Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE) VP:72 @ 100F
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 5%
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:XYLENE VP:5.1 @ 68F
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 3%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:SOLVENT NAPHTHA; (AROMATIC PETROLEUM DISTILLATE BP
    350-180F) VP:5.2 @ 100F
CAS:64742-94-5
RTECS #:WF3100000
Fraction by Wt: 0%
OSHA PEL:N/K 
ACGIH TLV:N/K 

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:YES    IARC:YES	  OSHA:NO
Health Hazards Acute and Chronic:INHAL:MAY CAUSE NOSE & THROAT IRRIT.
    MAY CAUSE NERV SYS DEPRESS CHARACT BY FOLLOWING PROGRESSIVE
    STEPS:HDCH, DIZZ, NAUS, STAG GAIT, LASSITUDE, LOSS OF COORD,
    CONFUSN, UNCON. SKIN/EYE CONT:MAY CAUSE IR RIT/BURNING OF EYES.
    RPTD/PRLNGD LIQ CONT MAY CAUSE SKIN IRRIT W/DISCOMFORT & DERM. EYE
    WATERING, HDCHS NAUS, DIZZ, ETC, ARE SIGNS THAT SOLV LEVELS ARE TOO
    HIGH. SKIN ABSORP:SEE INHAL. ORG SOLVS ARE E ASILY ABSORBED. DRY
    SKIN, REDNESS/DERM DUE TO DEFAT ACTION OF SOLVS ARE SIGNS OF EXPOS.
    INGEST:SEE INHAL. MAY ALSO RSLT IN GI DISTRESS. THERE IS DANGER OF
    PETROL DISTILLS ENTERING LUNGS IF SWALLOWED/V OMIT & CAUSING
    INFLAM, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE:IARC MONOGRAPHS SUPP,
    VOL 7, PH 194, 1987:GROUP 2B. NTP 7TH ANNUAL RPT ON CARCINS, 1994:
    ANTIC TO BE CARCIN. ANIMAL:LUNG, LIVER, SALIVARY, MAMMRY GLAND
    (TUMORS).
Effects of Overexposure:HLTH HAZS: DMG/EVEN DEATH. RPTS HAVE ASSOC RPTD
    & PRLNGD OVEREXP TO SOLV W/PERM BRAIN & NERV SYS DMG. LAB STUDIES
    W/RATS HAVE SHOWN THAT PETROL DISTILLS CAUSE KIDNEY DMG &
    KIDNEY/LIVER TUMORS. THESE E FTS WERE NOT SEEN IN SIMILAR STUDIES
    W/GUINEA PIGS, DOGS/MONKEYS. SEVERAL STUDIES EVALUATING PETROL
    WORKERS HAVE NOT SHOWN SIGNIFICANT INCREASE OF KIDNEY DMG/INCREASE
    IN KIDNEY/LIVER TUMORS. TOLUENE A PPEARS ON NAVY LISTING OF OCCUP
    CHEM REPRO HAZS. SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS
    CONCERNING LATEST HAZ LIST INFO & SAFE HNDLING & EXPOS INFO .
    INTENTIONAL MISUSE BY DELIB CONCEN TRATING AND INHALING VAPORS OF
    (SUPDAT)
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN AND
    RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
    PRODUCT.

=======================  First Aid Measures  =======================

First Aid:INHALATION:REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP,
    PREF MOUTH-TO-MOUTH. CALL MD. EYE:IMMED FLUSH W/PLENTY OF WATER FOR
    @ LST 15 MIN. CALL MD. SKIN:WASH W/SOAP & WATER. IF IRRIT OCCURS,
    CONT  MD. INGEST:CALL MD IMMED, HAVE NAMES OF HAZ INGS READY, DO
    NOT INDUCE VOMIT, KEEP HEAD LOWER THAN WAIST. ASPIR OF VOMIT MAY
    RSLT IN CHEM PNEUM &/OR PULM EDEMA.

=====================  Fire Fighting Measures  =====================

Flash Point Method:TCC
Flash Point:-256F,-160C
Lower Limits:1%
Upper Limits:13%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
    PROTECTIVE EQUIPMENT . AVOID CONFINED SPACES. WATER MAY BE
    UNSUITABLE AS AN EXTINGUISHING MEDIUM.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY ACCUM IN LOW AREAS
    OF POOR VENT/TRAVEL ALONG GROUND TO ROMOTE IGNIT SITES. CONTENTS
    ARE UNDER PRESS. KEEP COOL. EXPOS TO HEAT/SUNLIGHT MAY CAUSE CANS
    TO BURST & PROPELL CONTENTS . WATER FROM FOG NOZZS MAY BE HELPFUL
    IN COOLING UNRUPTURED CNTNRS TO PVNT PRESS BUILD-UP.

==================  Accidental Release Measures  ==================

Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION,
    INCLUDING HOT METAL SURFACES. WEAR APPROPRIATE CLOTHING AND GEAR.
    PREVENT SKIN CONTACT AND AVOID BREATHING OF VAPOR. CONFINE
    IMMEDIATELY AND REMOVE WITH INE RT ABSORBENT SUCH AS CLAY OR SAND.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:OBSERVE ALL LBL PRECS. KEEP AWAY FROM
    HEAT, SPKS, OPEN FLAME (I.E. ALL IGNIT SOURCES). CAP CNTNR AFTER
    EACH USE.DO NOT STORE ABOVE 120F.
Other Precautions:WASH HANDS THORO AFTER HNDLG & BEFORE EATING/SMKING.
    STORE IN DRY, WELL VENT PLACE. DO NOT EXPOSE TO DIRECT SUNLIGHT TO
    AVOID BURSTING. DO NOT SPRAY NEAR FIRE/FLAME. AVOID UNNEC CONT. DO
    NOT TAKE INTE RNALLY. DO NOT PUNCTURE CNTNRS. USE WITH ADEQUATE
    VENTILATION-DO NOT INHALE VAPORS. DO NOT SAND, FLA ME CUT, (SUPDAT)

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:DO NOT BRTHE VAPS/MISTS. IF TLV, PEL/OTHER LIMS
    ARE EXCEEDED THEN WEAR PROPERLY FITTED VAP & PARTICULATE/POS PRESS
    AIR SUPPLIED RESP APPRVD BY NIOSH/MSHA FOR USE W/PAINTS DURING
    APPLICATN & UNTIL ALL  VAPS & SPRAY MISTS ARE EXHSTED. FOLLOW RESP
    MFR'S DIRECTIONS FOR PROPER USE.
Ventilation:PROVIDE SUFFICIENT VENT IN VOL & PATTERN TO KEEP CONTAMS
    BELOW APPLIC OSHA REQS/OTHER SUGGESTED EXPOS LIMS. USE ONLY EXPLO
    PROOF EQUIP W/FLAM MATLS.
Protective Gloves:NEOPRENE GLOVES OR BETTER.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
    APRON, COVERALLS/WORK CLOTHES. CHANGE CLOTHES & SHOES IN CASE OF
    SPILL, SPLASH/EXCESSIVE OVERSPRAY. DO NOT REUSE CLTHG/SHOES WHILE
    SOLV ODOR IS (SUPDAT)
Work Hygienic Practices:AS WITH ALL CHEMICAL PRODUCTS, USE CARE IN
    HANDLING. DO NOT SMOKE OR EAT WITHOUT FIRST WASHING YOUR HANDS.
Supplemental Safety and Health
EFTS OF OVEREXP: THIS PRODUCT MAY BE HARMFUL OR FATAL. OTHER PREC:
    BRAZE/WELD DRY COATING WITHOUT A NIOSH/MSHA APPROVED RESPIRATOR OR
    SUFFICIENT VENTILATION. OTHER PROT EQUIP: RETAINED IN THEM. PROTEC
    TIVE CREAMS ARE NOT RECOMMENDED FOR PROTECTION BUT MAY BE USED FOR
    EASE OF CLEANUP.

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:>-43F,>-42C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.74 (H*2O=1)
VOC Grams/Liter:5.42
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:AEROSOL CAN

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS AND BASES, SELECTED AMINES.
Stability Condition to Avoid:NONE REASONABLY FORESEEABLE.
Hazardous Decomposition Products:MAY EMIT FUMES WHEN HEATED TO DECOMP.
    MAY EMIT CARBON MONOXIDE, CARBON DIOXIDE, UNIDENTIFIED ORG CMPDS.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
    WATER SYSTEMS. DISPOSE OF ABSORBED MATERIAL IN ACCORDANCE WITH ALL
    FEDERAL, STATE AND LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED
    CONTAINERS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.